Search Results for ‘t-case’

My WJ 4.0 with The over advanced Quadra drive system is making a rumbling or rubbing sound and it’s kinda loud when turning at slower speeds not always but pretty often and I suspect it coming from the T-Case as there was red fluid in it so I ordered the Mopar stuff and pumped most old fluid out...

Hey guys, It's been a while since I've posted here -- normally I can subsist by using the "search" function a whole bunch to get answers to my questions, but I want to get a few other voices in on this before I make a decision. Long story short, my other half and I are selling our beloved ZJ...

So here's the deal....I have an 06' Rubicon, 4" Currie Suspension lift, Antirock Sway bars, Currect Link Steering Upgrade, 1" JKS Motor Mount, 1" Body lift, 35x12.5 Goodyear Wranglers on 15x8 Mickey Thompson Classic II's. A few months ago, I started to notice a driveline vibration around...

Hi, I have a 2006 Jeep Wrangler Unlimited (not Rubicon) where the transfer case broke and needs to be replaced as reviewed by an auto repair shop. I would like to try to replace this with my son. This will be my sons vehicle in a year when he turns 16 so he needs to earn it by fixing it...

Hello All, I have a 96 jeep cherokee laredo 4.0 and I think there is a problem with the transfer case. It started out making a banging noise in the front middle. Then it sounded like a chain spinning in the t-case. It would not move and continued to make the spinning noise until I put it in...

will a 96 np231 out of wrangler work with my 89 i know the 96 has vss can i make it machanical and are the splines the same

I bought a 1980 CJ7 and have been slowly going through it and fixing/replacing just about everything it seems. This is the first jeep I have owned and I am not what I would consider even close to a mechanic. I am doing some of the stuff on my own but having someone else do what is over my head...

OK, so after replacing the rear seal on the T-case 2x & still having a leak, I took it to the mechanic. My issue was that the groove for the rear slinger locating ring (snap ring to the rear of the seal) was hidden underneath the seal itself & installing the ring damaged the seal & caused...

Hello. I am new to jeepforum. I purchased an xj over the summer with 125k on it. Now it won't move in any gear and it won't hold in park. The issue started after the "blizzard" we had here last week. I used 4wd often before they were able to plow my roads. I was driving to work after the...

hey everyone, i was wondering if i were to run a 2.5 inch suspension lift then 1 or 1.5 inch coil spacers for an overall lift of 3.5 or 4 inches, would i need a sye? Can i just drop my t-case and if so, how much would i drop it. Can anybody reccomend a good coil spacer too? thanks

I swapped in a 242WJ from a 01 i6 a few months ago. Everything went smoothly other than a vibration, mostly due to the case being long and drive shaft angle. Lately the vibration has increased and I am getting slight whine under 35 mph. Not very loud and all the time the vehicle is rolling...

Hello, so i have been on the forum for about a year, and have gotten so much useful information but i have yet to actually put up any write ups. So i will start with this quick project i did the other day. I love an "old school" look, and am always coming up with new way to make my tj look...

Im in need of the spirial brake cone in the clutch pack in Borg Warner 1305/1339 Quadra Trac transfer cases. There are no parts avalible anywere I have found for these clutch packs.

ok soo my buddy buys a lifted 4 door built by BDS and he's comming down US23 about 30k miles later and his t-case detonates. now its not a rubi but i'm wondering if i should put a rubi t-case back in or if i'll have any problems doing that?? i know the 4 to 1 low is nice to have but is it much...

I have a 97 with a 4cyl and the AX5 Transmission. My T-Case blew apart this past week and I found the correct T-Case on craigslist from what I can tell... 21 Spline NP231 I do have concerns though... The donor vehicle is a 1988 Jeep Cherokee with a 4cyl and AX5 Trans. Is this t-case going...

I have a 91 YJ Renegade with an auto trans. While driving in 2 wheel drive, I have a ticking or clicking noise that seems to be coming from the front of the transfer case that speeds up and slows down with vehicle speed. When I shift into 4x4 the cllicking goes away or changes to a squeak...

Hi, I noticed this grinding sound coming from the front part of my Cherokee after i put it into 4WD. I have looked under the front end as much as i could with out removing anything. and everything looks fine. no rubbing of the drive shaft or tires. the CV joints look fine. I don't know what it...

So, here's what I'm experiencing. I just installed a RC 4" suspension lift. I drove it about 10 miles before installing the T-case drop kit. I had to drive it to work that day, and about 1 mile from home I started getting this loud bang or popping noise. Almost sounds like a chain slipping...

hello i just joined this site i have had a couple jeeps before ( 2 XJs ) mainly for offroading only. but just recently (2 months ago) i bought my latest project its a 1998 Jeep Grand Cherokee 5.9 Limited all original. i did not know how special these things were until i started researching on...