JeepForum.com

JeepForum.com (http://www.jeepforum.com/forum/)
-   Grand Cherokee General Discussion (http://www.jeepforum.com/forum/f197/)
-   -   4x4Jeep's build thread.. (http://www.jeepforum.com/forum/f197/4x4jeeps-build-thread-1341031/)

4x4Jeep 03-10-2012 12:26 PM

4x4Jeep's build thread..
 
finally decided to make one...i bought my 2001 jeep Grand Cherokee with 84,600 miles on it in July '10 for about $8000, but had to finance it. came with a 2 year/24k mile warranty...saved me hundreds of $ in repairs. been paying $240/month and have about 1.5 years left. this one is my 2nd Jeep, i had a '93 XJ i owned a few years back, but never wheeled it. it broke down on me had had to sell it. would buy another one if i could.

BUILD LIST
(highlighted the important stuff)

*FL Leather Low-Back Bucket Seats
-AZ Agate
ADBP Protection Group
ADE Cold Weather Group
AFFP Luxury Group
AHC Trailer Tow Group
APAS Monotone Paint
ATC Radio-CD/Cass/10 Disc/Infinity Spkrs
AWSS Smoker's Group
A24P 4.0L Engine(ERH)/4Spd Auto Trans(DGK
BAZS 136 Amp Alternator
BC6S 625 Amp Maintenance Free Battery
BRYS Anti-Lock 4-Wheel Disc Brakes
CACS Low Back Bucket Seats
CBWS Highline Door Trim Panel
CFNS Rear 60/40 Folding Seat
CGWS Next Generation Front Air Bags**
CKDS Floor Carpet
CKNS Cargo Compartment Carpet
CKRP Cargo Net
CKTS Cargo Tie Down Loops
CLEP Front & Rear Floor Mats
CLGP Covered Cargo Storage
CLHS Cargo Trim Panel w/Storage Net
CLPS Door Sill Scuff Pads
CSCP Cargo Compartment Cover
CSRS Passenger Assist Handles
CUDS Mini Overhead Console
CUFS Full Length Floor Console
DGBS All 4-Speed Automatic Transmissions
DGK 4-Spd. Automatic 42RE Transmission
DHAS Lock-Up Torque Converter
DHPS Selec-Trac Full Time 4WD System
DJJS Dana 30/186MM Front Axle
DMEP 3.73 Rear Axle Ratio
DRMS Dana 35C/194MM Rear Axle

EAAC All Engines
ERH 4.0L I6 Power Tech Engine
GBBS Tinted Windshield Glass
GCBS Front Door Tinted Glass
GEGS Deep Tint Sunscreen Glass
GEPS Flipper Liftgate Glass
GFAS Rear Window Defroster
GNCP Sun Visors w/Illum Vanity Mirrors
GNKP Rear View Auto Dim Mirror
GTMP Power Heated Mirrors
GWA Power Sunroof
GXMP Remote Keyless Entry
GXXS Sentry Key Theft Deterrent System
HAAS Air Conditioning
HGAS Hood Insulation
HGDS Deluxe Insulation Group
I60S Route 60 - CSX, Westboro, MA
JAYS Instrument Cluster w/Tach
JCBS 120 MPH Primary Speedometer
JHAS Var Intermittent Windshield Wipers
JHBS Rear Window Wiper/Washer
JJAP Cigar Lighter
JJBS Dual Note Electric Horns
JJJP 12V Auxiliary Power Outlet
JKAS Locking Glove Box
JKPS 12V Auxiliary Power Outlet
JKYS Power Accessory Delay
JPBS Power Locks
JPDS Power Windows, Driver One-Touch
JPXP Power 10-Way Heated Seats
K4AS STRIPE/BADGE/MOLDING/COLOR
K5AS STRIPE/BADGE/MOLDING/COLOR
LACS Illuminated Entry
LAGS Warning Chime
LAZP Vehicle Information Center
LBBS Courtesy Lamps
LBCS Glove Box Lamp
LBDS Ash Tray Lamp
LCES Rear Courtesy/Reading Lamps
LDAS Underhood Lamp
LDBS Cargo Compartment Lamp
LETP Traveler/Mini Trip Computer
LMBS Halogen Headlamps
LMGP Automatic Headlamps
LNJ Fog Lamps
LPSS CHMSL Lamp
LSAP Security Alarm
MDAP Front License Plate Bracket
MFZS Bright Grille
MHAS Black Windshield Moldings
MVBS Grand Cherokee Badge
MVCS Jeep Badge
MVDS 4X4 Badge
MWGS Roof Rack
NAE California Emissions
NBUP Ultra Low Emission Vehicle (ULEV)
NFPS 20.5 Gallon Fuel Tank
NHMS Speed Control
PS5 Silverstone Metallic Clear Coat
QS5S Silverstone Metallic Clear Coat
RAAC All Radio Equipped Vehicles
RBPP AM/FM Cass/CD Radio w/Changer Ctrl
RCEP Infinity Speakers
RDDS Fixed Long Mast Antenna
RDPP 10-Disc Remote CD Changer
RDZP Steering Wheel Mounted Audio Ctrls
SBAS Power Rack and Pinion Steering
SCLP Leather Wrapped Steering Wheel
SDAS Normal Duty Suspension
SUAS Tilt Steering Column
TBLS Inside Mounted Spare Tire
TBW Full Size Matching Whl Spare Tire
TR7P P225/75R16 OWL All Season Tires
TZAP Goodyear Brand Tires
WDSS 16X7.0 Forged Aluminum Wheels
WLZC All Aluminum Wheels
XEYP Trailer Tow Wiring Harness
XGDP Universal Garage Door Opener
XPFS Protective Coating and Remover
YAAS Build To U.S. Mkt. Specifications
YEP Manuf Statement of Origin
YGCA 7 Additional Gallons of Gas
ZKGP Spring - Left Front
ZKYP Spring - Left Rear
ZYGP Spring - Right Front
ZYYP Spring - Right Rear
Z6DP GVW/Payload Rating

my plans are...3" IRO, 30" or 31" tires, AEV oil pan skid, KC driving lights, 16" JK steel wheels, IRO TC skid, and if i get a winch i'll get a custom built winch plate into the brush guard. it's my daily driver for now, and wheel it at least once a month, sometimes more.

this is the day i bought it...last time it was that clean:D
http://farm7.staticflickr.com/6139/5...e9ce56ef_z.jpg
http://i200.photobucket.com/albums/a...d/IMG_1042.jpg
http://i200.photobucket.com/albums/a...d/IMG_1051.jpg

the only thing i bought for it was a k&n air filter

August '10 i took it to Ocala NF for the 1st time to see what it could do.
http://i200.photobucket.com/albums/a...a/IMG_1866.jpg
a little bit of flexing
http://i200.photobucket.com/albums/a...a/IMG_1876.jpg
http://i200.photobucket.com/albums/a...a/IMG_1873.jpg
found a nice mud hole
http://i200.photobucket.com/albums/a...uddle_0004.jpg

http://i200.photobucket.com/albums/a...d/IMG_1703.jpg

that November '10 i drove to Upstate NY (Catskill's) to go backpacking for a week, then drove to Long Island to visit family. put a couple thousand miles on it, never gave me trouble.
upstate NY
http://i200.photobucket.com/albums/a...d/IMG_2196.jpg
http://i200.photobucket.com/albums/a...d/IMG_2203.jpg
http://i200.photobucket.com/albums/a...d/IMG_2242.jpg
http://i200.photobucket.com/albums/a...d/IMG_2243.jpg
parked behind another WJ
http://i200.photobucket.com/albums/a...d/IMG_2281.jpg

sold my hood deflector, got tired of the look. also sold my 10 disc cd changer, i didn't use it much.

at this time i was still new to off roading and didn't know anyone who was into that. i would occasionally go to wheeling by myself.
http://i200.photobucket.com/albums/a...uild/Ocala.jpg
http://i200.photobucket.com/albums/a...Build/Mudd.jpg

4x4Jeep 03-10-2012 12:27 PM

bought Jeep seat towels instead of custom seat cover cause of the huge price difference..they do get annoying but come in handy.
http://i200.photobucket.com/albums/a...d/IMG_3122.jpg

got some Husky floor liners front/rear. then i bought a used Husky liner for the cargo area, from someone on JF.
http://i200.photobucket.com/albums/a...d/IMG_3521.jpg

in January 2011 i took a trip to N. FL to go canoeing for a few days
http://i200.photobucket.com/albums/a...d/IMG_2894.jpg

bought the Mopar (OEM) front tow hooks and removed the ugly mud flaps
http://i200.photobucket.com/albums/a...d/IMG_3462.jpg
http://i200.photobucket.com/albums/a...d/IMG_3466.jpg
http://i200.photobucket.com/albums/a...d/IMG_3470.jpg


finally found some people (no jeeps though) to go wheeling with, we met at a gas station and rode out there together, a place called 5a, which in the spring/summer it is flooded with mud holes.
http://i200.photobucket.com/albums/a...d/IMG_3660.jpg
http://i200.photobucket.com/albums/a...d/IMG_3510.jpg
http://i200.photobucket.com/albums/a...d/IMG_3514.jpg
http://i200.photobucket.com/albums/a...d/IMG_3501.jpg
got stuck
http://i200.photobucket.com/albums/a...ld/mestuck.jpg
after i got home
http://i200.photobucket.com/albums/a...d/IMG_3518.jpg

no one there could believe what my wj did with it being all stock, including myself.

since then i had installed a rear tow hook
http://i200.photobucket.com/albums/a...d/IMG_3628.jpg
http://i200.photobucket.com/albums/a...d/IMG_3624.jpg
http://i200.photobucket.com/albums/a...d/IMG_3622.jpg

reached 100k miles
http://i200.photobucket.com/albums/a.../100kmiles.jpg

another time, same area...went with a twin WJ (sohcvtec1995)
http://i200.photobucket.com/albums/a...d/IMG_3656.jpg
http://i200.photobucket.com/albums/a...d/IMG_3659.jpg
http://i200.photobucket.com/albums/a...d/IMG_3658.jpg
http://i200.photobucket.com/albums/a...d/IMAG0283.jpg
and of course i got stuck
http://i200.photobucket.com/albums/a...d/mestuck2.jpg

this time i wasn't so lucky, after that day been having tranny problems. i don't make much money so the jeep sat in my driveway for almost 6 months before getting it fixed. too much money to rebuild the trans. so ended up putting a used one in. got one with about 50k miles on it installed for $1500 w/ a 6 month warranty.

while it was sitting for months...i bought a new battery, lightly tinted my taillights..
http://i200.photobucket.com/albums/a...d/IMG_3853.jpg
http://i200.photobucket.com/albums/a...d/IMG_3852.jpg
http://i200.photobucket.com/albums/a...d/IMG_3851.jpg

cleaned the TB
http://i200.photobucket.com/albums/a...d/IMG_3815.jpg
http://i200.photobucket.com/albums/a...d/IMG_3816.jpg

put in new headlights
http://i200.photobucket.com/albums/a...d/IMG_3810.jpg
before
http://i200.photobucket.com/albums/a...d/IMG_3812.jpg
after
http://i200.photobucket.com/albums/a...d/IMG_3817.jpg

4x4Jeep 03-10-2012 12:27 PM

after i got the heep running again i was so anxious to get it dirty took it in some mud at night and ended up braking the steering stabilizer, then when i was being pulled out, my bumper got hooked up on something and ripped it completely off along with the grille.
http://i200.photobucket.com/albums/a...d/IMG_4040.jpg
http://i200.photobucket.com/albums/a...d/IMG_4071.jpg

decided to buy a limited style grille and paint it the body color and paint the chrome trim black.
http://i200.photobucket.com/albums/a...d/IMG_4164.jpg
http://i200.photobucket.com/albums/a...d/IMG_4177.jpg

met up with some other Jeeps and went to Ocala NF
http://i200.photobucket.com/albums/a...e/IMG_4229.jpg
britheman's zj
http://i200.photobucket.com/albums/a...e/IMG_4224.jpg
MrJ's dub
http://i200.photobucket.com/albums/a...e/IMG_4231.jpg
stuck in sugar sand
http://i200.photobucket.com/albums/a...uild/stuck.jpg
http://i200.photobucket.com/albums/a...IMG_4228-1.jpg
http://i200.photobucket.com/albums/a...d/IMG_4220.jpg
some mud holes
http://i200.photobucket.com/albums/a...11_57_54-1.jpg

i bought a brush guard off craigslist for $80, bought a cb, and painted the grille silverstone metallic to match my jeep.

that last trip i met someone who welds (billyzj) and since i like the look of the brush guards, but it takes the front tow hooks away, he fabbed up a way to have both.

we bolted to steel plates where you would normally mount the tow hooks to. and mounted the brush guard to them
http://i200.photobucket.com/albums/a...d/IMG_4246.jpg

then welded d-rings to the bottom plates
http://i200.photobucket.com/albums/a...e/IMG_4254.jpg

Uniden PRO505xl and a 4' Firestik Firefly
http://i200.photobucket.com/albums/a...e/IMG_4219.jpg
http://i200.photobucket.com/albums/a...e/IMG_4235.jpg
http://i200.photobucket.com/albums/a...e/IMG_4236.jpg
used a dodge ram hood mount
http://i200.photobucket.com/albums/a...e/IMG_4300.jpg

also bought new dash speaker/tweeters...sound great
new vs old
http://i200.photobucket.com/albums/a...e/IMG_4371.jpg
http://i200.photobucket.com/albums/a...e/IMG_4372.jpg

some wheeling shots
http://i200.photobucket.com/albums/a...IMG_4352-1.jpg
http://i200.photobucket.com/albums/a...e/IMG_4410.jpg
http://i200.photobucket.com/albums/a...e/IMG_4296.jpg
http://i200.photobucket.com/albums/a...e/IMG_4279.jpg
http://i200.photobucket.com/albums/a...e/IMG_4351.jpg


then i bought a 2" bb off ebay $90 shipped, and a Rancho steering stabilizer
found it too difficult to install myself i had some help from some buddies.
http://i200.photobucket.com/albums/a...e/IMG_4380.jpg
bottomed out after the 2" boost
http://i200.photobucket.com/albums/a...e/IMG_4376.jpg

4x4Jeep 03-10-2012 01:37 PM

some more shots since my latest mods
http://i200.photobucket.com/albums/a...e/IMG_4393.jpg
http://i200.photobucket.com/albums/a...e/IMG_4389.jpg
http://i200.photobucket.com/albums/a...e/IMG_4390.jpg
http://i200.photobucket.com/albums/a...e/IMG_4428.jpg
http://i200.photobucket.com/albums/a...e/IMG_4440.jpg

about 2 weeks ago my transmission went again. engine would rev, but wouldn't go anywhere.
http://i200.photobucket.com/albums/a...225_232117.jpg
took it back to the same shop cause of the warranty they said it was a shift solenoid and replaced it. was driving home, about half way it got stuck again, and right now its back at the shop and they said it should be done by monday or tuesday. they might have to put another used transmission in, but either way it's free. should definitly be ready for my next trip...March 17 & 18

4x4Jeep 03-13-2012 01:17 PM

shop said they are waiting on a new (used) tranny....hopefully it's soon

peytonimor7 03-15-2012 11:43 AM

Lookin great so far! The lights and brushguard really made a difference with the front end. That's real cool that you incorporated shackles with your brush guard too. Sorry to hear about your tranny trouble, but atleast it's still under warranty.

I hope you can get it working again for your next wheeling trip the 17th! That's my birthday and I'll finally be 18 so I can go to Gulches here in SC. I love the look of a muddied up Laredo. A rear autolocker would really help with that mud, and it won't cost 1k like a set of mud tires would :D

4x4Jeep 03-15-2012 02:23 PM

thanks. i actually have a front bumper sitting in the garage...plan to cut it in half (seen a few wj's like that) that way it won't interfere with the brush guard mounting and it'll still cover up the upper part of the bumper.

they said the trans. will be done saturday morning, i'll be wheeling saturday afternoon into sunday.

never thought about a locker...don't know too much about them, but aren't they $500+ and tires should only be $800 for me but either way i can only dream:drool: about those, until i make more $$

4x4Jeep 03-22-2012 02:03 PM

problem after problem i finally picked up the jeep today. they ended up just rebuilding it for me, and i didn't have to pay a cent:D so brand new parts, makes no more noises and i'm happy. just in time for Jeep Jam too.

as soon as i got home i fabbed up a bumper i had sitting around, cut it in half cause the d-rings i have were in the way of the slotted stuff on the bumper. also fixed my horn...boy did i miss it :laugh:

tomorrow i'll pick up some grade 8 bolts to mount the brush guard with. here's how it sits now:

http://i200.photobucket.com/albums/a...d/IMG_4450.jpg

http://i200.photobucket.com/albums/a...d/IMG_4447.jpg

http://i200.photobucket.com/albums/a...d/IMG_4449.jpg

in the future i'll prob paint the cladding and bumpers black

4x4Jeep 03-24-2012 11:38 PM

good day of wheelin' for me, not so much for the heep

on my way to jeep jam my newly rebuilt transmission started to overheat. i lost 4th gear, and i thought i was done for the day, but from reading the owners manual and talking with the mechanic i decided i could still attempt to drive to the event (since i preregistered)

my first jeep event i been to; was a good time...they had a stock, moderate and extreme course. ran the stock course 3x. then me and a buddy went to citrus wma for the first time and that turned out to be some awesome trails, for florida anyway. i did however blow my reverse...not sure how.

some pics and vids
http://i200.photobucket.com/albums/a...p/IMG_4452.jpg
http://i200.photobucket.com/albums/a...p/IMG_4474.jpg
http://i200.photobucket.com/albums/a...p/IMG_4453.jpg
http://i200.photobucket.com/albums/a...p/IMG_4465.jpg
blew a front left tire so the mud part was closed for a while :(
http://i200.photobucket.com/albums/a...p/IMG_4459.jpg
http://i200.photobucket.com/albums/a...p/IMG_4468.jpg
http://i200.photobucket.com/albums/a...p/IMG_4471.jpg

http://youtu.be/WpGBKlOp6Tc

citrus wma
http://i200.photobucket.com/albums/a...p/IMG_4482.jpg

http://www.youtube.com/watch?v=qTrne...zu0Por3fqxU%3D
http://www.youtube.com/watch?v=o9Gz-...Ob5oRL8SpxM%3D
http://www.youtube.com/watch?v=LlJJa...3SpIR1CNgAo%3D

alwaysHI 03-25-2012 12:08 AM

could be a snap ring issue in your trans that caused the reverse to go.
definitely liking the halved bumper!

snobrdrkid07 03-25-2012 12:08 PM

Looks like you are having a lot of fun with the Jeep man! Sucks to hear that you are having some more problems with your transmission! Once I smelled a fluid after pulling hard through some mountains I realized that it was time for large auxiliary cooler was a must! Keep us posted man!

Jeep - Just Empty Every Pocket!

4x4Jeep 03-25-2012 01:36 PM

Quote:

Originally Posted by alwaysHI (Post 13298382)
could be a snap ring issue in your trans that caused the reverse to go.
definitely liking the halved bumper!

from what i read seems so.

thanks..i did a fast job on it too.

4x4Jeep 04-01-2012 01:17 PM

jeep is still being worked on, meanwhile i bought some used 4" rough country shocks for the wj, have a friend who is going to sell me some 3.5" springs, another buddy selling me the RC adjustable track bar and some front disco's. when i get some money saved up i'll be buying those. and also putting away some $$ for 31" treadwrights. :thumbsup:

mrJ 04-01-2012 05:37 PM

There's 32's on CL right now. Brand new I think. And you don't need discos. I just took the front sway bar off

alwaysHI 04-01-2012 10:57 PM

hows it ride on the highway like that?


The time now is 07:23 AM.

Powered by vBulletin Version 3.8.4
Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.